The Electrical Contractor Network

ECN Electrical Forum
Discussion Forums for Electricians, Inspectors and Related Professionals

Books, Tools and Test Equipment for Electrical and Construction Trades

Register Now!

Register Now!

We want your input!

Featured:
   

2017 NEC and Related
2017 NEC
Now Available!

   
Recent Posts
230 or 345 kV transmission lines?
by Vlado
Yesterday at 09:33 AM
breaker meltdown
by crselectric
Yesterday at 12:42 AM
Electrical mast flashing product
by ThomasWinfrey
09/22/16 12:14 AM
What estimating software do you recommend?
by sparky
09/21/16 07:20 PM
"Dry Run" Inspection goes awry
by HotLine1
09/20/16 07:39 PM
New in the Gallery:
12.5A through 0.75mm˛ flex (just out of curiosity)
Shout Box

Top Posters (30 Days)
HotLine1 15
sparky 9
gfretwell 9
sparky66wv 8
Vlado 6
Who's Online
0 registered (), 246 Guests and 4 Spiders online.
Key: Admin, Global Mod, Mod
Topic Options
Rate This Topic
#181793 - 10/30/08 11:13 PM Alert!: Laptop batteries recalled over fire threat
Trumpy Offline

Member

Registered: 07/05/02
Posts: 8530
Loc: SI,New Zealand
From Stuff.co.nz:
 Quote:
The US government has issued a recall of 35,000 Sony Corp notebook computer batteries, calling them a fire hazard to consumers.

The US Consumer Product Safety Commission said the recall affects Sony lithium-ion batteries that were used mainly in computers from Hewlett-Packard Co, with a smaller number in notebooks from Dell Inc and Toshiba Corp.

There have been 19 reports of the batteries overheating, including 17 reports of fire, the CPSC said, with two people experiencing minor burns.

Sony spokeswoman Elizabeth Boukis would not speculate on the cost of the recall.

The company will support the US recall, along with that of an additional 65,000 batteries worldwide.

On a global basis, PC makers have reported 40 overheating incidents, Sony said.

The recall affects around 32,000 HP notebooks, 3000 from Toshiba, and 150 Dell computers.

HP could not be immediately reached for comment.

Sony blamed the faulty batteries on manufacturing line adjustments in 2004 and 2005, which it believes may have affected the quality of some cells. Other incidents of overheating may have involved a problem with raw materials, the company said.

Boukis said batteries covered by the new recall are unrelated to those in company's massive 2006 recall.

That action covered 9.6 million batteries and cost the company millions.

In addition, last month the consumer electronics giant recalled 438,000 of its Vaio laptops due to battery overheating concerns.


Link: Story @ Stuff
_________________________
Let's face it, these days if you're not young, you're old - Red Green grin

Top
Test Equipment:

Large Selection of Test Equipment For Electrical, HVAC, Test & Measurement
Large Selection of Test Equipment For Electrical, HVAC, Test & Measurement

#182005 - 11/14/08 09:10 PM Re: Alert!: Laptop batteries recalled over fire th [Re: Trumpy]
Theelectrikid Offline
Member

Registered: 04/30/04
Posts: 854
Loc: Levittown, PA
We can't get Lithium batteries to work in laptops, and we want them in hybrid/electric cars?

Oh well.

Ian A.


Edited by Theelectrikid (11/14/08 09:18 PM)
_________________________
Is there anyone on board who knows how to fly a plane?

Top
#182134 - 11/19/08 12:10 AM Re: Alert!: Laptop batteries recalled over fire th [Re: Theelectrikid]
pdh Offline
Member

Registered: 01/20/05
Posts: 354
Lithium batteries work fine when manufactured correctly. The issue is one of higher and higher energy density vs. cheaper and cheaper manufacturing by the lowest bidder.

Top
#182147 - 11/19/08 10:43 AM Re: Alert!: Laptop batteries recalled over fire th [Re: pdh]
SteveFehr Offline
Member

Registered: 03/19/05
Posts: 1192
Loc: Chesapeake, VA
The problem with better and better batteries is that those better batteries come with inreasingly dense chemical energy, which makes them more useful but also more dangerous. Lithoium-ion batteries are within the same order of magnitude of chemical density as TNT! To make matters worse, lithium-ion was delayed to market for years because they catch fire so incredible easily from overcharging and overdischarging; it wasn't until protective circuity was developed that they became widely adopted.

Anecdote: when lithium-ion batteries first made their way into cell phones, pilots of ultra-light indoor R/C planes would dismantle the battery packs to put them on their planes, removing all the protection, but carefully sizing the motors and all to within the same limits of the battery. But if the propellor happened to hit something (like the ground) while the pilot still had the throttle on... that locked-rotor current would send the Li-ion into thermal overrun within seconds. They had a similar problem with charging. The fancy smart-chargers will let you dial-a-setting... and if that setting is too high... heh.

Apparently, the Tesla roadster offers supercar performance from its li-ion battery... but don't try to track it, because under race conditions, the battery will overheat and catch fire!

Top
#182162 - 11/19/08 07:06 PM Re: Alert!: Laptop batteries recalled over fire th [Re: SteveFehr]
noderaser Offline
Member

Registered: 03/01/07
Posts: 405
Loc: Portland, Oregon, United State...
There's a local guy who drag races his custom-built electric car, who recently made the change to Li-Ion batteries. Their weight/power ratio over the (assuming lead-acid) batteries he has before means he lays waste to gas cars even quicker!

Video story from local PBS station here: http://www.opb.org/programs/ofg/videos/view/56-Electric-Drag-Racing
_________________________
http://www.hsiprodsvcs.com/

Top
#182234 - 11/21/08 10:43 AM Re: Alert!: Laptop batteries recalled over fire th [Re: noderaser]
SteveFehr Offline
Member

Registered: 03/19/05
Posts: 1192
Loc: Chesapeake, VA
Well, drag races are one place you don't need to worry about overheating the battery smile It's a different issue if you take it to a road course like the Nurbergring in Germany where the fastest time requires constant full accelleration followed by as hard of braking as you can to make the corner, followed immediately by accellerating as hard as you can, etc. Brakes end up glowing cherry red and Tesla battery packs end up... well... more of a smouldering black from what I hear wink

Electric cars are just going to slaughter on the drag strip. They're just so easy to make go so fast, the tradeoffs are completely different than for gasoline engines. I imagine they'll do extremeley well at Autocross, too.

Top
#182240 - 11/21/08 11:46 AM Re: Alert!: Laptop batteries recalled over fire th [Re: SteveFehr]
gfretwell Offline

Member

Registered: 07/20/04
Posts: 9012
Loc: Estero,Fl,usa
In any long race the problem with electrics will be "refueling". I assume the rules would allow swapping batteries in a pit stop. In that regard it would be as fast as dumping fuel in a tank.
I am really thinking about making my Prelude electric
_________________________
Greg Fretwell

Top
#182407 - 11/25/08 11:17 AM Re: Alert!: Laptop batteries recalled over fire th [Re: gfretwell]
SteveFehr Offline
Member

Registered: 03/19/05
Posts: 1192
Loc: Chesapeake, VA
Hybrid-electric with regenerative braking might do well... issue with that, is that it's hard to get regenerative braking to work well enough to stop a car at the limit of tire traction, and thus not very practical for a race car.

I know of a company out in Colorado takes cars and turns them into electric vehicles smile From what I hear, it's actually rather affordable (as in, less than the price of a new car), though certainly not economic- you'll never make your money back off it.

Top
#182418 - 11/26/08 12:51 AM Re: Alert!: Laptop batteries recalled over fire th [Re: SteveFehr]
gfretwell Offline

Member

Registered: 07/20/04
Posts: 9012
Loc: Estero,Fl,usa
The reason I looked at doing the Prelude is it is really just a Civic in a sports jacket and they have a lot of parts for that conversion. When my cam belt breaks that is my plan.
_________________________
Greg Fretwell

Top



ECN Electrical Forums - sponsored by Electrical Contractor Network - Electrical and Code Related Discussion for Electrical Contractors, Electricians, Inspectors, Instructors, Engineers and other related Professionals